The gearbox oil level can be checked with the engine off, when the machine is on level ground, and when the gearbox housing is cool enough to touch.
Unscrew the filler plug, check the oil level and add oil in small portions. If the level is too low, add oil to the correct level and then tighten the plug.
Note: When driving, the temperature of the oil in the box can be very high. Before checking the oil level, allow the oil in the box and filler plug to cool. In order to protect the environment, the used oil and container should be delivered to special disposal sites.
Brake fluid hydroscopic, and the presence of moisture in the brake fluid will cause damage brake system. Therefore, the brake fluid must be changed in accordance with this manual. ... Power steering fluid level With the engine cold, the power steering fluid level should be between the "maximum" and "minimum" marks on the expansion tank. If the level is below...Other on site:
Camshaft. Camshaft axles
1. Remove the yoke axle and yokes (p. 2.8). 2. Remove the camshaft driven pulley (p. 2.6.14-2.6.16). 3. Take out camshaft from the cylinder head to the flywheel. Val carefully...
Relieving pressure in the power supply system of gasoline engines
Remember that gasoline is a highly flammable liquid! Observe all applicable fire safety precautions when working on power system components. Do not smoke! Don't go near the...
Removal and installation of the lock of a cover of the hatch of a bulk pipe of a fuel tank and its drive
You will need: all the tools needed to remove the rear trim of the left floor sill and trunk trim, as well as a “10” socket. 1. Remove the front and rear facings of the left f...
fans Chery Amulet don't try to point something else vehicle. They highly appreciate just such an interesting car, they are ready to do everything so that the car pleases them with pleasant trips for a longer time. If you are also a fan of this car, it will be useful to find out how the process is carried out in the Chery Amulet car. You should not trust your "treasure" to the masters at the service station. At a minimum, you will have to lose a certain amount of money, but to be sure that such technical procedure perform the highest quality, it is not always possible. It is for this reason that we recommend learning how to change the oil yourself. If you follow the recommendations, you will solve this technical issue just as well.
Instructions for changing the oil in the Chery Amulet gearbox.
Replacement process
The car will work flawlessly if all consumables are changed in time. The gearbox needs periodic replacement. If you ignore this requirement, at some point you simply will not be able to shift gears, or the car will refuse to move at all. Of course, you need to prepare for any action. We will help you find out in what sequence and what specific actions you will need to perform.
Replacement frequency
Often you will not have to pour gear oil into the gearbox. The manufacturer recommends that complete replacement after forty thousand kilometers or four years of operation. At the same time, we draw attention to the fact that both of these indicators should not be met, it is enough that one of them meets the requirements. Many car owners rarely drive their car, believing that with such economical operation they will be able to save on the purchase of consumables. However, this is a misconception, in the event of constant downtime, the transmission fluid loses its technical characteristics, so it becomes unable to ensure correct operation. manual transmission.
Level check
If most often you have to change the oil after the specified period, then in some cases, some car owners still have to resort to such technical manipulation for other indications. Due to even minor defects, TM leakage may occur, which is important to eliminate in time. If you are on the road, it will definitely not be possible for you to inspect the gearbox, look for the cause of the TM leak, but it is also impossible to continue the trip without doing anything.
We recommend checking the oil in the box to make sure that the level is within the acceptable range. Unfortunately, if the checked oil level in the box is below normal, you will need to top up the missing amount of oil fluid.
To perform this procedure, first unscrew the filler plug, arm yourself with a dipstick and check. Sometimes it is difficult to distinguish an old oil mark from a new one, so it is recommended that you first wipe the dipstick thoroughly with a rag, eliminating all traces of oil, and only then measure the level. Please note that the rag should provide a good cleaning of the surface of the probe, but at the same time not leave a single fluff on it. You can not use old woolen textiles, since all the fibers first fall on the surface of the dipstick, and then into the oil, provoking a deterioration in its technical parameters.
Which oil to choose
In any car store you can find a stand that presents all kinds of gear oils that differ in different parameters. Do not rush to buy the first one that you liked according to some inexplicable criteria. It is impossible to fill in the first oil that comes across at the checkpoint, especially if you expect to extend the life of your car.
There are three types of oils:
- mineral;
- semi-synthetic;
- synthetic.
We immediately warn you that you will have to be tempted to purchase. The cost of this TM is much lower than the prices of synthetics or semi-synthetics. However, don't skimp. Mineral oil has low technical specifications, it will not be able to ensure the normal operation of the checkpoint. Ask your dealer if they have a high quality transmission Trans KP Super 75W-90 Semisynthetic. It is it that meets all the requirements, ensuring the successful operation of the gearbox.
If such gear oil is not available for sale, a car dealership employee will be able to find a decent analogue for you, follow his recommendations, but only on condition that this car dealership is trustworthy.
Tools and consumables
Do not rush to leave the store immediately after purchasing TM. To carry out the procedure, you will need some tools:
- hexagon on "10";
- syringe;
- container for waste collection.
If something from this small list is not at your disposal, then purchase the tools directly from the auto shop.
Procedure
After you have successfully prepared for the process of replacing the transmission fluid with your own hands, you can safely proceed to the next steps. We recommend warming up the car first. This is important in order to increase the temperature of the HM, in which case the mining will flow out faster. You can even take a ride so as not to drive the engine just like that. Then drive Cherie Amulet onto a flyover or viewing hole, if there is one in your garage. This is necessary in order to provide unhindered access to the drain hole.
Unscrew the filler plug, you can check the oil level to see if there are any other additional problems. Now unscrew drain plug, substitute the container, mining will immediately begin to flow into it. Wait until the old oil is completely drained. After that, you can tighten the drain plug.
Armed with a syringe, fill in a new transmission fluid into the gearbox housing. Finally, check the oil level and, making sure that everything is within acceptable limits, tighten the filler plug. Now your car is ready to please you again with its excellent work.
So, we hope that the process of replacing TM did not seem difficult to you, and you will do an excellent job with this task. Anyone who has changed the oil at least once on their own will never even think about resorting to the help of service station specialists.
11.11.2016
Probably, many new car owners were most annoyed by the need to carry out all maintenance work at a car service: otherwise you could lose the warranty. But as soon as the warranty expires, you gradually begin to do most of the work yourself. In particular, this applies to the replacement of vehicle fluids, brake pads, tie rod ends and so on. So changing the oil in the gearbox is considered an event that, as a rule, does not cause any problems for motorists. Especially when it comes to such inexpensive and easy-to-install cars as Chery Amulet.
Changing the oil in the box is, of course, a rather rare procedure in terms of frequency (every 40,000 kilometers). Meanwhile, if you do not want to do expensive things in the future, you need to do this in accordance with the manufacturer's instructions. Today we want to talk about the features of changing the oil in the Amulets gearbox, using just one simple tool (10 hex wrench), a large syringe (especially for filling oils), several tens of minutes of free time and a couple of liters of type GL-4 or SAE 75W -90.
For the convenience of performing the operation, it is necessary to change the oil either in the pit or on the flyover. So, let's prepare a container for draining the used oil and go under the car: access to the drain and filler holes is located there.
In order to facilitate and speed up the work, it is recommended to change the oil in the box within 15 minutes after turning off the engine. In this case, the oil will be hot and liquid, which will allow it to quickly release the internal cavities of the gearbox. Also, in order to avoid getting burns, you should very carefully unscrew the drain plug.
Fans of Chery Amulet should not try to orient themselves to another vehicle. They highly appreciate just such an interesting car, they are ready to do everything so that the car pleases them with pleasant trips for a longer time. If you are also a fan of this car, it will be useful to find out how the process of changing the gearbox oil is carried out in the Chery Amulet car. You should not trust your "treasure" to the masters at the service station. At a minimum, you will have to lose a certain amount of money, but it is not always possible to be sure that such a technical procedure will be performed with the highest quality. It is for this reason that we recommend learning how to change the oil yourself. If you follow the recommendations, you will solve this technical issue just as well.
Instructions for changing the oil in the Chery Amulet gearbox.
Replacement process
The car will work flawlessly if all consumables are changed in time. The gearbox needs periodic replacement of the transmission fluid. If you ignore this requirement, at some point you simply will not be able to shift gears, or the car will refuse to move at all. Of course, you need to prepare for any action. We will help you find out in what sequence and what specific actions you will need to perform.
Replacement frequency
Often you will not have to pour gear oil into the gearbox. The manufacturer recommends a complete replacement after forty thousand kilometers or four years of operation. At the same time, we draw attention to the fact that both of these indicators should not be met, it is enough that one of them meets the requirements. Many car owners rarely drive their car, believing that with such economical operation they will be able to save on the purchase of consumables. However, this is a misconception, in the event of constant downtime, the transmission fluid loses its technical characteristics, so it becomes unable to ensure the correct operation of the manual transmission.
Level check
If most often you have to change the oil after the specified period, then in some cases, some car owners still have to resort to such technical manipulation for other indications. Due to even minor defects, TM leakage may occur, which is important to eliminate in time. If you are on the road, it will definitely not be possible for you to inspect the gearbox, look for the cause of the TM leak, but it is also impossible to continue the trip without doing anything.
We recommend checking the oil in the box to make sure that the level is within the acceptable range. Unfortunately, if the checked oil level in the box is below normal, you will need to top up the missing amount of oil fluid.
To perform this procedure, first unscrew the filler plug, arm yourself with a dipstick and check the transmission fluid level. Sometimes it is difficult to distinguish an old oil mark from a new one, so it is recommended that you first wipe the dipstick thoroughly with a rag, eliminating all traces of oil, and only then measure the level. Please note that the rag should provide a good cleaning of the surface of the probe, but at the same time not leave a single fluff on it. You can not use old woolen textiles, since all the fibers first fall on the surface of the dipstick, and then into the oil, provoking a deterioration in its technical parameters.
Which oil to choose
In any car store you can find a stand that presents all kinds of gear oils that differ in different parameters. Do not rush to buy the first one that you liked according to some inexplicable criteria. It is impossible to fill in the first oil that comes across at the checkpoint, especially if you expect to extend the life of your car.
There are three types of oils:
- mineral;
- semi-synthetic;
- synthetic.
We warn you right away that you will have to be tempted to purchase mineral oil. The cost of this TM is much lower than the prices of synthetics or semi-synthetics. However, don't skimp. Mineral oil has low technical characteristics, it will not be able to ensure the normal operation of the gearbox. Ask the auto shop if they have a high quality transmission semi-synthetic oil TNK Trans KP Super 75W-90 Semisynthetic. It is it that meets all the requirements, ensuring the successful operation of the gearbox.
If such gear oil is not available for sale, a car dealership employee will be able to find a decent analogue for you, follow his recommendations, but only on condition that this car dealership is trustworthy.
Tools and consumables
Do not rush to leave the store immediately after purchasing TM. To carry out the procedure, you will need some tools:
- hexagon on "10";
- syringe;
- container for waste collection.
If something from this small list is not at your disposal, then purchase the tools directly from the auto shop.
Procedure
After you have successfully prepared for the process of replacing the transmission fluid with your own hands, you can safely proceed to the next steps. We recommend warming up the car first. This is important in order to increase the temperature of the HM, in which case the mining will flow out faster. You can even take a ride so as not to drive the engine just like that. Then drive Cherie Amulet onto a flyover or viewing hole, if there is one in your garage. This is necessary in order to provide unhindered access to the drain hole.
Unscrew the filler plug, you can check the oil level to see if there are any other additional problems. Now unscrew the drain plug, substitute the container, mining will immediately begin to flow into it. Wait until the old oil is completely drained. After that, you can tighten the drain plug.
Armed with a syringe, pour new transmission fluid into the gearbox housing. Finally, check the oil level and, making sure that everything is within acceptable limits, tighten the filler plug. Now your car is ready to please you again with its excellent work.
So, we hope that the process of replacing TM did not seem difficult to you, and you will do an excellent job with this task. Anyone who has changed the oil at least once on their own will never even think about resorting to the help of service station specialists.
vibormasla.ru
How to change the oil in a Chery Amulet gearbox
11.11.2016Probably, many owners of new cars were most annoyed by the need to carry out all routine maintenance at a car service: otherwise, you could lose warranty obligations. But as soon as the warranty expires, you gradually begin to do most of the work yourself. In particular, this applies to the replacement of vehicle fluids, brake pads, tie rod ends, and so on. So changing the oil in the gearbox is considered an event that, as a rule, does not cause any problems for motorists. Especially when it comes to such inexpensive and easy-to-install cars as Chery Amulet.
Changing the oil in the box is, of course, a rather rare procedure in terms of frequency (every 40,000 kilometers). Meanwhile, if you do not want to make expensive repairs to Chery Amulet in the future, you need to do this in accordance with the manufacturer's instructions. Today we want to talk about the features of changing the oil in the Amulets gearbox, using just one simple tool (a 10 hex wrench), a large syringe (especially for filling oils), several tens of minutes of free time and a couple of liters transmission oil for Cherie Amulet type GL-4 or SAE 75W-90.
For the convenience of performing the operation, it is necessary to change the oil either in the pit or on the flyover. So, let's prepare a container for draining the used oil and go under the car: access to the drain and filler holes is located there.
- Loosen the filler hole with a 10 wrench to allow air to enter and facilitate oil leakage.
- With the same key, unscrew the drain hole, after substituting a container for used oil under it.
- After the oil has completely drained out, we wipe the drain hole, its plug and screw the latter into place.
- Having typed new oil into the syringe, we gradually fill the gearbox, trying the level with a finger through the filler hole: the normal level is along its very bottom edge.
- We twist the plug of the filler hole, wipe the gearbox from oil residue.
In order to facilitate and speed up the work, it is recommended to change the oil in the box within 15 minutes after turning off the engine. In this case, the oil will be hot and liquid, which will allow it to quickly release the internal cavities of the gearbox. Also, in order to avoid getting burns, you should very carefully unscrew the drain plug.
You might be interested in: How to remove and install the cladding yourself trunk Chery Amulet
zapchasti-chery.com.ua
Checking the level and changing the oil in the Chery Amulet gearbox since 2006
4.3.17. Checking the level and changing the oil in the gearbox
carmn.ru
Manual.CountryAuto.ru:
You will need: a 10 hex wrench, a container for collecting used oil, a syringe.
1. Place the vehicle on a lift or pit.
6. ... and drain the oil into a prepared container.
7. Wrap the drain plug.
8. Pour fresh oil from the syringe into the gearbox housing to the lower level of the oil filler hole.
9. Wrap a stopper of an oil-filling aperture of a transmission.
manual.countryauto.ru
Timing belt replacement every 100,000 km -Replacement drive belts: diesel engine every 40.000 km Gas engine every 60,000 km of run - Change the oil in a gasoline engine every 10,000 km of run in a diesel engine every 5,000 km of run - Change the oil filter at every oil change - Change the coolant every 40,000 km of run - Change the spark plugs every 20,000 km of run - Change the diesel fuel filter engine every 20,000 km petrol engine every 40,000 km - Change air filter every 40,000 km - Change air conditioner filter every 40,000 km - Change brake fluid every 40,000 km - Check clutch fluid every 10,000 km - Check power steering fluid every 10,000 km - Oil change in manual transmission every 20,000 km - Oil change in automatic transmission every 20.000 km - Oil change in transfer case every 20.000 km of run - Oil change in differentials every 20.000 km of run - Grease change in hub bearings every 20.000 km of run - Lubrication of crosspieces cardan shaft every 10,000 km But what people say: Engine oil: 5-10,000 km Along with the oil is always a filter. Oil in manual box: 50.000 km Fluid in the machine: no more than 40.000 km. When changing the fluid, the Toyota instruction tells you to unscrew the box pan, remove the strainer, rinse it and the pan in fresh automatic transmission fluid and put it back. In this case, do not blow the magnets located on the pallet. There is NO need to change the filter. Practice shows that it is also not necessary to wash it. Practice also shows that replacing automatic transmission fluid sometimes miraculously affects the smoothness and correctness of gear shifting. At your obedient servant, the machine gun somehow began to fool around, twitch and stall when starting and stopping. Easy replacement liquids without any flushing cured the problem in the bud Fuel filter: 40.000 km. Although most do not change the filter at all, until the car starts to run poorly on high speed(not enough gasoline due to a clogged filter). Practice shows that the filter can not be changed for many years, but one refueling with crappy gasoline with mechanical impurities is enough to clog it badly. Air filter: 40.000km, blow every 10.000km. Antifreeze: every 40.000 km. Candles: ordinary - every 20,000 km, platinum - every 100,000 km with normal gasoline Only those candles that are indicated in the instructions should be installed. As a rule, these are NGK and ND (Nippon Denso, now renamed Denso). Bosch and other Champions are better not to bet - they, as a rule, have other parameters. Belts: every 100.000 km. Brake fluid and power steering fluid: every 40,000 km. It is possible / necessary to fill in the power steering ATF oil(the same oil as in the automatic transmission). This is during normal, leisurely use in normal conditions. If the operating conditions of your machine differ from normal - draw conclusions. And for oil brush I advise MannoL 75W-90 in a red can, it switches perfectly to both cold and hot