This part is a paper or felt air-cleaning element that protects the air-fuel mixture preparation chamber from various contaminants such as dust and sand. This is an integral element necessary for the correct operation of an internal combustion engine.
A poor-quality or worn-out filter will allow dust and other small particles into the engine. This can lead to incorrect operation of the internal combustion engine and other unpleasant aspects. Remember that early replacement of the Toyota Camry v40 and v50 air filter is the key to maintaining a long engine life.
When to replace
Typically, the regularity of purchasing a new filter is 15-30 thousand kilometers, however, this is an individual indicator for each car. It largely depends on weather conditions and terrain. In urban environments or desert areas, clogging will occur much faster. The best way to determine the condition of the filter is to perform a visual inspection. If the part is black or dark brown, it means it's time to buy a new air filter.
Neglecting replacement can lead to several consequences, in particular:
- Increased fuel consumption.
- Significant loss of power.
- Increased carbon dioxide (CO2) content in the exhaust.
- In the long term - engine failure and the need for major repairs.
Changing the air filter in a Toyota Camry
The air filter is located in the engine compartment of the car. Before starting work, we recommend preparing several rags, a set of spanners (preferably with a ratchet, since space is limited) and a new filter. To change the air filter in a Camry, follow these simple steps:
This completes the entire procedure. If the filter box is in a clean state, then everything is much simpler, since you just need to insert a new filter to replace the old one.
Every car owner can replace the air filter in his garage. You do not have to contact an expensive service center and pay money for this simple procedure. Never skimp on buying a filter, as its cost (compared to a major engine overhaul) is simply incommensurable.
A high-quality filter element, as Toyota engineers expect, can ensure reliable cleaning of the air entering the combustion chambers of the cylinders for 40 thousand kilometers. However, when determining the timing of the next replacement, you should take into account the quality of the installed replacement element and the operating conditions of the vehicle. It is quite possible that the recommended replacement period may be slightly reduced.
It is known that the quality of air purification directly affects the quality of mixture formation in the cylinders. Perhaps a loss of power and increased fuel consumption are signs of a dirty air filter in your car.
When the filter element is heavily contaminated, some particles from the outside begin to penetrate into the heart of the car, leading to irreversible consequences. Increased wear of rubbing parts in the engine, contamination of the engine oil - all this does not contribute to increasing the service life of the engine.
If, due to your own forgetfulness, you cannot determine the date of the previous replacement, then you should look under the hood to visually assess the condition of the air filter on your Toyota Camry. If the filter is confirmed to be dirty, then replacement should begin.
Replacement procedure
The air filter is located in the engine compartment on the right side. To replace the replacement element, you will need to open the cover of the filter box, for which you need to open special latches.
When removing a used element, you should pay attention to its condition. It is the contamination of the filter, taking into account the actual mileage, that will allow you to coordinate the frequency until the next replacement under equal operating conditions of the machine.
Before installing a new element, thoroughly clean the inside of the box, and only then install a new filter.
When purchasing a filter element, preference should be given to the original product, or a good analogue produced by a well-known company. Unnecessary savings in this case can lead to further ruinous costs associated with engine maintenance.
After the work is completed, be sure to mark the date and mileage of the vehicle at the time the service was performed. This can be done in a separate weekly journal, or by placing the tag in an accessible place directly on the air filter box under the hood.
Video material
The process of replacing the air filter on a Toyota Camry is clearly demonstrated in the video presented:
Air filters installed on Toyota Camry 40 cars with 2.4 and 3.5 liter engines have similar materials, but different dimensions and shapes. For this reason they are not interchangeable.
The Toyota Camry 40 is equipped with an original air filter with article number 1780128030. Its cost is about 700-800 rubles. When contacting an official service station, replacing the filter element can cost about 2,000 rubles.
ATTENTION! A completely simple way to reduce fuel consumption has been found! Don't believe me? An auto mechanic with 15 years of experience also didn’t believe it until he tried it. And now he saves 35,000 rubles a year on gasoline!
The filter is made of synthetic material. It has a frameless structure. The manufacturer is the Japanese company Denso.
For the American market, the company produces filters with article number 178010H050. They are completely similar to the original, but their price is higher and amounts to 900-1000 rubles.
Good analogues and their prices are shown in the table below.
Air filters used on Camry 40 with a 3.5-liter power plant
On a Camry 40 with a 3.5-liter power unit, a filter with article number 1780131120 is installed. It has a different shape from the consumables intended for a 2.4-liter engine. The cost of a filter element starts at 600 rubles and ends at about 750.
There is an analog filter created for the American market. Its article number is 17801AD010. The price is higher - from 850 to 950 rubles. Both filters have completely similar characteristics.
Good analogues that can replace the branded filter on a 3.5-liter Camry 40 are shown in the table below.
The process of replacing the air filter on a Camry with a 2.4 liter engine
- Open the hood. The air filter is located next to the engine. The air duct pipe fits to it.
- Using a Phillips screwdriver, unscrew the two bolts. This will allow you to disconnect the housing.
- Use your fingers to lift the lid as shown in the photo below.
- Remove the old filter.
- Install a new one.
- Tighten the 2 bolts connecting the two halves of the housing.
Replacing the filter on a 3.5-liter engine
Replacing the air filter on a car with a 3.5-liter engine differs from the process on a Camry 40 with a 2.4-liter engine. The algorithm for changing the filter element is as follows:
- Gain access to the engine compartment.
- Remove the negative terminal from the battery.
- Remove the filter housing cap. To do this, you need to release special clamps.
- Remove the old filter.
- Close the housing.
- Replace the negative terminal of the battery.
The recommended replacement frequency, according to reviews from car owners, is 20,000 km. In this case, it is necessary to take into account the operating conditions of the vehicle. It is important to monitor the condition of the filter every 10 thousand km.
When replacing the air filter on a 2.4 liter engine, there is a risk of losing the housing cover bolt. In this case, you must purchase spare fasteners with article number 9009904593.
In addition to replacing the filter element, it is sometimes advisable to completely clean the filter. To do this, follow the sequence below:
Restoring the filter element
Many car owners experiment with cleaning the filter element. For these purposes, various chemicals are used, for example, car shampoo. Washing the old filter does not give the desired effect.
In addition to the discrepancy between the service life of the restored filter and the new one, there is a risk of foreign particles entering the engine. Ultimately, this will shorten the life of the engine before major repairs, and the money saved on consumables will be spent on restoring the internal combustion engine.
On average, it is recommended to change the air filter every 10,000 - 15,000 km, depending on the operating conditions of the vehicle. The influence of the air filter on engine performance is difficult to overestimate. Depending on the degree of contamination, the quality of air entering the piston system changes. Dirt that accumulates on the filter can flake off and enter the engine along with the air stream, which leads to a decrease in its efficiency, as well as a shortening of its service life. Remember that a car, like a person, needs clean air.
To replace the air filter, it is not at all necessary to contact an official service center, since you can remove and diagnose it yourself without special technical skills. If, after examining the filter, you decide not to change it for now, then it is advisable to at least clean the inner walls of the casing and box in which it is located.
Step-by-step instructions on how to replace the engine air filter with your own hands: photo + video.
The filter box on the Toyota Camry is located to the right of the engine. In early models, the box was secured with two bolts. In the latest Camry models, the box is secured with two plastic latches on springs. Move them aside or unscrew the bolts.
Lift the box and remove the filter. If you just want to clean it and not replace it with a new one, you can use a vacuum cleaner. Also wipe the chamber where the filter element is located with a rag.
Install the new filter and fasten the latches back/or tighten the bolts. Now your car can breathe deeply.
Also watch the video: Replacing the engine air filter on a Toyota Camry with your own hands:
Save money on paying third-party specialists and time on a visit to a car service center by making replacing the Camry 40 air filter body yourself. The procedure does not require skills or equipment.
If you notice: The car's power has decreased, fuel consumption has increased - the cause may be a dirty filter. Air access to the engine deteriorates, some of the fuel burns, and exhaust toxicity increases.The atmospheric air is filled with grains of dust, fine pollutants, and aerosols that have a detrimental effect on the internal combustion engine. Optimistically, a clogged filter will have to be changed after 15 thousand kilometers.
Sequence of operations
It is advisable to buy the original or entrust a professional to select a worthy analogue at a cheaper price.
The filter looks like this:
It's time to pop the hood of your car and get to work. A car enthusiast who does not know the structure of the car will have a question: “Where is the filter located?” In the box - pictured in the center:
Unfasten the 3 latches on the box (without any effort, with your hands). Lift the box lid, slide it to the right and remove the filter that needs replacing. Install the purchased filter, put the lid back on and secure the structure with latches. The process will take a minute and a half maximum. And you will spend the lion's share of time printing out the product packaging.
Are you unsure which side to place the filter in the box? Place it so you can read the markings (see photo 1).
Thrifty craftsmen vacuum and wash the dirty filter. We consider the procedures to be ineffective. For normal operation, you must make replacing the air filter of Toyota Camry V40.
Please note: when replacing the filter, you do not need specific knowledge, a diploma as a car mechanic or many years of experience in a service station, no tools are used. Forget about visits to a car service center. A child can cope with the task, not to mention an adult who knows how to drive a vehicle.
We hope the illustrated article was useful.